充磁方式对永磁无刷直流电机激振力波的影响

樊晓波; 胡利民

doi:10.11993/j.issn.1673-1948.2016.06.009

充磁方式对永磁无刷直流电机激振力波的影响

doi: 10.11993/j.issn.1673-1948.2016.06.009

中国船舶重工集团公司第705研究所昆明分部, 云南昆明, 650106

详细信息

作者简介:
樊晓波(1982-), 男, 硕士, 高级工程师, 研究方向为电动力技术.

中图分类号: TJ630.32; TM351
计量
- 文章访问数: 1281
- HTML全文浏览量: 2
- PDF下载量: 423
- 被引次数: 0
出版历程
- 收稿日期: 2016-10-11
- 修回日期: 2016-10-18
- 刊出日期: 2016-12-20

Influences of Magnetizing Modes on Exciting Force Waves of Permanent Magnet Brushless DC Motor

Kunming Branch of the 705 Research Institute, China Shipbuilding Industry Corporation, Kunming 650106, China

摘要

摘要: 为降低水下航行器用永磁无刷直流电机(PM BLDCM)的振动与噪声影响, 针对PM BLDCM在不同充磁方式下电磁激振力波存在差别的问题, 建立了PM BLDCM的有限元分析模型, 分别在空载和负载条件下, 对比分析了径向和平行2种充磁方式下气隙磁密的分布特点。基于Maxwell应力张量法计算电磁力, 完成了空载和负载条件下电机径向电磁激振力波的仿真, 对比了2种充磁方式对径向电磁力波的影响, 得到了其分布特点。研究结果表明, 空载和负载条件下, 电磁激振力波存在较大差异, 为确定充磁方式对电磁激振力波的影响, 需要在负载情况下完成分析; 与平行充磁相比较, 负载时径向充磁方式下, 主要频率的幅值均有所增大, 而其余频率的幅值有所降低。
- 水下航行器 /
- 永磁无刷直流电机 /
- 充磁方式 /
- 平行 /
- 径向 /
- 气隙磁密 /
- 电磁激振力波
Abstract: In order to reduce the vibration and noise of the permanent magnet brushless DC motor(PM BLDCM) for underwater vehicle, a finite element analysis model is established for PM BLDCM to investigate the difference between an electromagnetic exciting force waves of PM BLDCM with two different magnetizing modes. And the distribution characteristics of flux density of air gap for parallel and radially magnetizing modes in both no-load and load conditions are obtained and compared. Then, the electromagnetic forces are derived via the Maxwell stress tensor, and the electromagnetic force waves of PM BLDCM in both no-load and load conditions are simulated. The influences of two magnetizing modes on electromagnetic force waves are analyzed, and the distribution characteristics of the waves are achieved. The results show that in no-load and load conditions the electromagnetic exciting force waves are quite different, so the influence of load on exciting force waves must be considered in analyzing the influence of magnetizing mode on the exciting force waves; and compared with in parallel magnetizing mode, the amplitude of the main frequency increases in radially magnetizing mode but the amplitudes of other frequencies reduce.
- underwater vehicle /
- permanent magnet brushless DC motor (PM BLDCM) /
- magnetizing mode /
- parallel /
- radial /
- flux density of air gap /
- electromagnetic exciting force wave

HTML全文

参考文献(9)

[1]	陈永校. 电机噪声的分析与控制[M]. 杭州: 浙江大学出版社, 1987.
[2]	唐任远. 现代永磁电机理论与设计[M]. 北京: 机械工业出版社, 2006.
[3]	Kobayashi T, Tajima F, Ito M, et al. Effects of Slot Combination on Acoustic Noise from Induction Motors[J]. IEEE Transactions on Magnetics, 1997, 33(2): 2101-2104.
[4]	Torregrossa D, Peyraut F, Cirrincione M, et al. A New Passive Methodology for Reducing the Noise in Electrical Machines: Impact of Some Parameters on the Modal Analysis[J]. IEEE Transactions on Industry Applications, 2010, 46(5): 1899-1907.
[5]	朱德明, 严仰光. 表贴式永磁电机的两种充磁方式[J]. 南京航天航空大学学报, 2006, 38(3): 304-308. Zhu De-ming, Yan Yang-guang. Two Different Magnetization Manners in Surface Mounted Permanent Magnet Machine[J]. Journal of Nanjing University of Aeronautics & Astronautics, 2006, 38(3): 304-308.
[6]	沈建新, 费伟中, 陈利根. 气隙磁场波形及磁瓦充磁方式对无刷直流性能的影响[J]. 微特电机, 2006, 34(6): 7-9. Shen Jian-xin, Fei Wei-zhong, Chen Li-gen. Influence of Air Gap Field Distribution and Surface PM Magnetiztion in Brushless DC Motors[J]. Small & Special Electrical Machines, 2006, 34(6): 7-9.
[7]	李延升, 窦满峰, 赵冬冬. 磁钢充磁方式对表贴式永磁电机磁场影响分析[J]. 电机与控制学报, 2011, 15(12): 26-31. Li Yan-sheng, Dou Man-feng, Zhao Dong-dong. Analytical Magnetic Field of Magnetization Manners in Surface-mounted PM Motor[J]. Electric Machines and Control, 2011, 15(12): 26-31.
[8]	张冉, 王秀和, 乔东伟. 极弧系数选择对永磁无刷直流电机激振力波的影响[J]. 中国电机工程学报, 2010, 30(21): 79-85. Zhang Ran, Wang Xiu-he, Qiao Dong-wei. Influence of Polearc Coefficient on Exciting Force Waves of Permanent Magnet Brushless DC Motors[J]. Proceedings of the CSEE, 2010, 30(21): 79-85.
[9]	汤蕴缪. 电机内的电磁场[M]. 第2版. 北京: 科学出版社, 1998.